TheASD relay and fuel pump relay are located in the PDC near the battery. The inside top of the PCD cover has a label showing relay and fuse location. ASD and Fuel Pump Relays The following description of operation and tests apply only to the Automatic Shutdown (ASD) and fuel pump relays. The terminals on the bottom of each relay are numbered.

TestingSuzuki GSX-R1000 Fuel Pump Electrical Circuit. Check the fuel pump relay switch, which is located behind the battery. Hold it as you turn on the ignition, and check if you're able to feel the switch click on and off, which means it's working. Next, double-check that the relay is working by attaching a test light to the relay CASE1: The fuel pressure gauge registered 0 PSI. This confirms that the cause of your 2.0L, 2.4L Chrysler car or mini-van is caused by a lack of fuel. Now, I usually take one more precaution, before condemning the fuel pump as bad and this is to check that the fuel pump is getting 12 Volts as the engine is cranking. fuelpump relay: fuel pump relay: outlet relay: electric socket relays: headlight lo relay: headlamp relay (low) ig1 relay: ignition relay: front fog light relay: front anti-fog lamp relays: cooling fan relay no.2: cooling fan relay # 2: main relay: main relay: cooling fan relay no. 3: cooling fan relay # 3: drl relay: drl relay: horn relay
Thefuel pump relay on the early cars is located on the fuse / relay panel under the dash on the driver's side (LHD). The DME relay actually has two relays / contacts. If you suspect the DME relay is bad and you need to move the car, you may install do so by installing an "emergency" jumper across terminals 30, 87, and 87b on the relay
Itlooks like the orange to the fuel pump relay comes through the ecm so power is getting to the computer. Tomorrow I'll check for power to D on the relay from ecm A1 and check the green/white wire for continuity from A1 to D. If the wire is good and the ecm is powered from the fuse block to ecm A6 it looks like the ecm is bad.
However the replacement cost of the vehicle's fuel pump relay part alone is rather inexpensive. You can find the part at any auto parts store for between $20 to $50. Fuel pump relay FAQs Can a bad fuel pump relay cause misfire? Yes, there are several things a bad fuel pump relay can result in and a misfire is one of them.
Anotherthing you will want to check before replacing the fuse block is the fuel pump current. If the fuel pump is drawing too many amps, then it will burn out the fuel pump relay. You can do this right at the fuse block with the fuel pump relay remove. Just run a jumper across the fuel pump relay to get the pump to run and check the amp using
Otherthan the main relay , helpful way to diagnose another problem replacement parts can be bought from
.
  • vav55phfgo.pages.dev/798
  • vav55phfgo.pages.dev/127
  • vav55phfgo.pages.dev/460
  • vav55phfgo.pages.dev/61
  • vav55phfgo.pages.dev/429
  • vav55phfgo.pages.dev/723
  • vav55phfgo.pages.dev/854
  • vav55phfgo.pages.dev/711
  • vav55phfgo.pages.dev/638
  • vav55phfgo.pages.dev/531
  • vav55phfgo.pages.dev/433
  • vav55phfgo.pages.dev/829
  • vav55phfgo.pages.dev/409
  • vav55phfgo.pages.dev/87
  • vav55phfgo.pages.dev/441

    • when a fuel pump relay is bad